Product ID:ENAMEL,GLOSS BLUE 15050
MSDS Date:12/30/1986
FSC:8010
NIIN:00-159-4521
MSDS Number: BJNTV

PLASTI-KOTE COMPANY, INC.

1000 LAKE RD.
MEDINA, OH 44256
US

Emergency Phone: 216-725-1511

Info Phone: 216-725-1511

Cage: DO534

TEMPO PRODUCTS CO A PLASTI-KOTE CO INC

MEDINA, OH 44256 US

Telephone: 330-725-4511

Cage: 07708

METHYLENE CHLORIDE (SARA III)

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: 20-25%

OSHA PEL 500 PPM/C,1000; Z2

ACGIH TLV: 50 PPM, A2; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

VM & NAPHTHA (VP 15.0 MM HG @ 20C)

CAS: 8030-30-6

RTECS: DE3030000

Fraction By Weight: 10-15%

OSHA PEL 500 PPM

ACGIH TLV: 500 PPM/350 MG/M3

ACETONE (SARA III)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 20-25%

OSHA PEL 1000PPM

ACGIH TLV: 750PPM/1000STEL;9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PROPANE

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 25%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT; 9192

ISOBUTANE

CAS: 75-28-5

RTECS: TZ4300000

BUTANE

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 15-20%

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM; 9192

NON-HAZARDOUS INGREDIENTS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:REPEAT/PROLONG OVEREXPOSURE TO
SOLVENTS CAN CAUSE PERMANENT BRAIN/NERVOUS SYSTEM
DAMAGE.PROLONG/REPEAT SKIN CONTACT WITH METHYLENE
CHLORIDE:IRRITATION,DEFATTING,DERMATITIS.LOSS OF CONSCIOUS/DEATH AS
L OW AS 10,000PPM & CAUSE NUMBNESS ARMS/LEGS,RAPID HEART ABOVE
7000PPM.
Explanation of Carcinogenicity:METHYLENE CHLORIDE APPEARS ON ABOVE
AGENCIES LISTS OF SUSPECTED CARCINOGENS.
Effects of Overexposure:BREATH:EXCESS INHALE CAN CAUSE
NASAL/RESPIRATORY IRRIT,DIZZI,WEAK,FATIGUE,NAUSEA,HEADACHE,POSSIBLE
ASHYXIATION.EYE:SEVERE IRRIT RED,TEAR,BLUR VISION CONTACT LENS
SHOULD NOT BE WORN.SWALLOW:GASTROINTES TINAL
IRRIT,NAUSEA,VOMIT,DIARRHEA.SKIN:METHYLENE CHLORIDE IS PAINFUL &
IRRIT IF CONFINED TO SKIN BY GLOVES,CLOTHES,ETC.
Medical Cond Aggravated by Exposure:CAN CAUSE ALLERGIC RESPIRATORY
AND/OR SKIN REACTION.INTENT MISUSE:DELIBERATE CONCENTRATE/INHALE
CONTENTS MAY BE HARMFUL/FATAL.

First Aid:BREATHED:REMOVE PERSON TO FRESH AIR.IF BREATHING
DIFFICULT,ADMIN OXYGEN.IF BREATHING STOPPED,GIVE CPR & SEEK MED
AID.EYES:FLUSH W/H2O FOR 15 MIN WHILE OCCASION HOLD EYELIDS
OPEN,GET MED AID.SWALLOWED: DO NOT INDUCE VOMIT(ASPIRATION OF
MATERIAL INTO LUNGS CAN CAUSE CHEM PNEUMONITIS WHICH CAN BE
FATAL).KEEP PERSON WARM,QUIET,& GET MED ATTN/POISON CONTROL
CENTER.SKIN:WASH WITH SOAP/H2O/HAND CLEANER.

Lower Limits:1.0
Extinguishing Media:"ALCOHOL" FOAM. CO2 AND DRY CHEMICAL
Fire Fighting Procedures:USE H20 TO COOL CLOSED CONTAINER TO PREVENT
PRESS BUILDUP/EXPLODE/AUTO IGNITE FROM HIGH HEAT.FOG NOZZLE
PREFERED.USE SCBA W/FULL FACEPIECE IN POSS PRESSURE MODE
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR, MAY TRAVEL
ALONG GROUND/VENT & IGNITE BY FLAMES, SPARKS, HEATERS, OTHER
IGNITION SOURCES AT DISTANT LOCATIONS FROM HANDLING POINT.

Spill Release Procedures:ELIMINATE IGNIT SOURCE,EVACUATE
AREA,VENTILATE/AVOID BREATHING VAPORS.TURN OFF HEAT/AIR
CONDITIONING TO PREVENT VAPORS FROM CONTAMINATING BUILDING.ABSORB
LIQUID ON PAPER,VERMICULITE,FLOOR ABSORBENT AN D OTHER MATERIAL &
TRANSFER TO CLOSED CONTAINERS.

Handling and Storage Precautions:DO NOT STORE IN AREAS ABOVE 120F OR IN
DIRECT SUNLIGHT, OR NEAR HEAT OR OPEN FLAMES.DO NOT PUNCTURE OR
INCINERATE.
Other Precautions:NONE

Respiratory Protection:OCCASIONAL USE:AVOID BREATHING VAPORS/MIST.OPEN
WINDOWS,DOORS OR USE OTHER MEANS TO ENSURE FRESH AIR ENTRY DURING
APPLICATION/DRYING.IF YOU EXPERIENCE EYE
WATERING,HEADACHES,DIZZINESS INCREASE FRESH A IR.WEAR RESPIRATORY
PROTECTION.
Ventilation:FOR REGULAR/CONTINUOUS USE:PROVIDE SUFFICIENT
MECHANICAL(GENERAL) & LOCAL EXHAUST VENT TO MAINTIAN EXPOSURE BELOW
TLV'S.
Protective Gloves:CHEMICAL RESISTANT GLOVES (NEOPRENE,ETC)
Eye Protection:CHEMICAL GOGLES PER OSHA REGS.
Other Protective Equipment:SOLVENT-RESISTANT
BOOTS,APRON,HEADGEAR/FACESHIELD SHOULD BE WORN WHERE SPLASHING IS
POSSIBLE.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING WASHROOM.
MINIMIZE PERSONAL CONTACT AND BREATHING VAPORS.WASH CLOTHING BEFORE
RE-USE.
Supplemental Safety and Health

Boiling Pt:B.P. Text:104 TO 300F
Melt/Freeze Pt:M.P/F.P Text:1500F,816C
Vapor Density:HEAVIER
Spec Gravity:(H2O = 1)< 1
Evaporation Rate & Reference:< ETHER/> BUTYLE ACETATE
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT
Percent Volatiles by Volume:85-90

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, HEAT, ALKALIES HOT SURFACES AND REACTIVE
METALS
Stability Condition to Avoid:HEAT, SPARKS, AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS,NITROGEN
COMPOUNDS,ETC.C02,CO HYDROGEN CHLORIDE,PHOSGENE(SM AMT),VARIOUS
HYDROCARBONS WHEN BURN

Waste Disposal Methods:MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
DEPOSITED IN A POSTED TOXIC SUBSTANCE LANDFILL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.